Polaris Recalls RZR Pro XP and Turbo R Recreational Off-Road Vehicles Due to Fire Hazard (Recall Alert)
A fuel leak can occur at the fuel pump assembly joint on the fuel tank in close proximity to a hot surface, posing a fire hazard.
Read the official notice →
- Date
- 2023-05-18
- Country
- United States
- Brand
- Polaris
- Product
- Model Year 2021-2023 RZR Pro XP 4 and Model Year 2022-2023 RZR Turbo R 4 vehicles Recreational Off-Road Vehicles
- Units
- About 20,330 (In addition, about 330 were sold in Canada)…
- Category
- Vehicles
- Source
- CPSC
Copied automatically from the US Consumer Product Safety Commission. Details may be shortened or out of date; the official notice is the authoritative source. Disclaimer
What to do
- Check whether your vehicle is affected by entering its VIN (vehicle identification number) on the manufacturer's or the agency's recall lookup.
- Contact a dealer to book the repair. Recall repairs are normally free of charge.
- If the notice says not to drive or to park outside, follow that until the repair is done.
General guidance from Recall Atlas. The official notice from the US Consumer Product Safety Commission has the exact models, batch codes and remedy, and it takes priority.
More Polaris recalls
- 2024-11-22
DE
EUAll-terrain vehicle (Polaris) · RANGER XP Kinetic (UTV/ Side-By-Side)
The high-voltage cables on the engine control unit can become detached. This can lead to a voltage arc or overheating, which can result in a fire and/or unintentional acceleration. Moreover, unintentional acceleration…
- 2024-10-04
- DEEU
All-terrain vehicle (Polaris) · Sportsman 850, Sportsman XP 1000, Sportsman XP 1000 S
Water or other contaminants can accumulate on the fuel pump flange, where it can damage the pump flange, which can result in a fuel leak. A leak at the fuel pump’s flange outlet can lead to a risk of fire. The product…
- 2024-06-21
- DEEU
All-terrain vehicle (Polaris) · Ranger EV
Some vehicles have an unprotected wiring harness that can overheat, increasing the risk of fire and serious injury. The product does not comply with the Regulation on the approval and market surveillance of…
- 2023-04-21
- DEEU
All terrain vehicle (Polaris) · Sportsman 1000S, Scrambler 1000S
Fuel can to ignite if spilled during refuelling, creating a risk of fire and injury. The product does not comply with the Regulation on the approval and market surveillance of two- or three-wheel vehicles and…
- 2023-03-30
USPolaris Recalls RZR Recreational Off-Road Vehicles Due to Fire Hazard (Recall Alert)
The alternator can fail during operation, posing a fire hazard.
- 2023-03-24
- DEEU
Quadricycle (Polaris) · RANGER XP 1000, XP 1000 CREW, Ranger 1000, Ranger 1000 Crew
Fuel leaks can occur at the outlet connection of the fuel pump. Leaked fuel can ignite on hot components of the vehicle, creating a fire. The product does not comply with the Regulation on the approval and market…
Other vehicles recalls in the United States
- 2023-05-18
- US
International Motors, LLC: Obstructed Back-Up Lights/ FMVSS 108
Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
- US
Chrysler (FCA US, LLC): Steering Column Incorrectly Assembled
A loss of steering control increases the risk of a crash.
- US
REV Recreation Group: Tow Hitch May Separate
A tow vehicle that separates from the motorhome can become a road hazard, increasing the risk of a crash.
- 2023-05-17
- US
Nova Bus (US) Inc.: Seat Belt Not Retracting Properly/FMVSS 209
A seat belt that does not retract properly may result in a loose seat belt, which can increase the risk of injury in a crash.
- US
Foretravel, Inc.: Software Error in Vehicle Control Module
The loss of drive power, headlights, or windshield wipers can increase the risk of a crash.
- 2023-05-16
- US
Daimler Trucks North America, LLC: Turn Signal Malfunction/FMVSS 108
A nonfunctioning exterior turn signal may not notify other drivers of a turning vehicle, increasing the risk of a crash.