All-terrain vehicle (Polaris) · Ranger EV

Some vehicles have an unprotected wiring harness that can overheat, increasing the risk of fire and serious injury. The product does not comply with the Regulation on the approval and market surveillance of…

Date

2024-06-21

Country

Germany

Brand

Polaris

Product

All-terrain vehicle

Classification

fire, injuries

Category

Vehicles

Source

EU Safety Gate

Copied automatically from the European Commission's Safety Gate. Details may be shortened or out of date; the official notice is the authoritative source. Disclaimer

What to do

1. Check whether your vehicle is affected by entering its VIN (vehicle identification number) on the manufacturer's or the agency's recall lookup.
2. Contact a dealer to book the repair. Recall repairs are normally free of charge.
3. If the notice says not to drive or to park outside, follow that until the repair is done.

General guidance from Recall Atlas. The official notice from the European Commission's Safety Gate has the exact models, batch codes and remedy, and it takes priority.

More Polaris recalls

1. 2025-03-21
2. DEEU
   Vehiclesfire

   All-terrain vehicle (Polaris) · RZR XP 1000, RZR XP4 1000

   A missing battery pole cover at the positive pole the starter battery can lead to an electrical short circuit, increasing the risk of the vehicle catching fire. The product does not comply with the Regulation on the…

   EU Safety Gate · reported by GermanyPolarisOfficial notice →
3. 2024-11-22
4. DEEU
   Vehiclesfire, injuries

   All-terrain vehicle (Polaris) · RANGER XP Kinetic (UTV/ Side-By-Side)

   The high-voltage cables on the engine control unit can become detached. This can lead to a voltage arc or overheating, which can result in a fire and/or unintentional acceleration. Moreover, unintentional acceleration…

   EU Safety Gate · reported by GermanyPolarisOfficial notice →
5. 2024-10-04
6. DEEU
   Vehiclesfire

   All-terrain vehicle (Polaris) · Sportsman 850, Sportsman XP 1000, Sportsman XP 1000 S

   Water or other contaminants can accumulate on the fuel pump flange, where it can damage the pump flange, which can result in a fuel leak. A leak at the fuel pump’s flange outlet can lead to a risk of fire. The product…

   EU Safety Gate · reported by GermanyPolarisOfficial notice →
7. 2023-05-18
8. US
   Vehicles

   Polaris Recalls RZR Pro XP and Turbo R Recreational Off-Road Vehicles Due to Fire Hazard (Recall Alert)

   A fuel leak can occur at the fuel pump assembly joint on the fuel tank in close proximity to a hot surface, posing a fire hazard.

   CPSCAbout 20,330 (In addition, about 330 were sold in Canada)…Official notice →
9. 2023-04-21
10. DEEU
    Vehiclesfire, injuries

    All terrain vehicle (Polaris) · Sportsman 1000S, Scrambler 1000S

    Fuel can to ignite if spilled during refuelling, creating a risk of fire and injury. The product does not comply with the Regulation on the approval and market surveillance of two- or three-wheel vehicles and…

    EU Safety Gate · reported by GermanyPolarisOfficial notice →
11. 2023-03-30
12. US
    Vehicles

    Polaris Recalls RZR Recreational Off-Road Vehicles Due to Fire Hazard (Recall Alert)

    The alternator can fail during operation, posing a fire hazard.

    CPSCAbout 200 (In addition, about 2 were sold in Canada)Official notice →

Other vehicles recalls in Germany

1. 2024-06-21
2. DEEU
   Vehiclesinjuries

   Passenger car (Hyundai) · Elantra, Kona

   The vehicle's transmission software doesn't engage emergency mode when a fault occurs. This can lead to an unexpectedly severe deceleration, increasing the risk of accidents and injuries. The product does not comply…

   EU Safety Gate · reported by GermanyHyundaiOfficial notice →
3. DEEU
   Vehiclesinjuries

   Passenger van / Light commercial vehicle (Mercedes-Benz) · Sprinter, eSprinter

   The weld points of a B-pillar reinforcement are not solid enough. This can lead the transfer of the seatbelt forces to the B-pillar to fail. This increases the risk of injury during an accident. The product does not…

   EU Safety Gate · reported by GermanyMercedes-BenzOfficial notice →
4. DEEU
   Vehiclesinjuries

   Passenger car (Audi) · Q4 e-tron

   The electronic stabilisation control unit's pump motor may be missing up to all three screws. This can lead to the pump motor's detachment and can cause hydraulic brake failure, increasing the risk of accidents and…

   EU Safety Gate · reported by GermanyAudiOfficial notice →
5. 2024-06-19
6. DEEU
   Vehiclesinjuries

   Passenger car (Mini) · Countryman

   In the production process, the armrest support bracket may have been incorrectly screwed to the rear left or right door panel. In the event of an accident, the armrest bracket can become detached, damaging the thorax…

   EU Safety Gate · reported by GermanyMiniOfficial notice →
7. 2024-06-14
8. DEEU
   Vehiclesfire

   Passenger car (Audi) · e-tron GT, RS e-tron GT

   A combination of production issues (such as a torn anode tab, a folded cathode tab, a peeled-off cathode or a double production topic pouch crack) was found in some of the batteries' high-voltage modules. Over the…

   EU Safety Gate · reported by GermanyAudiOfficial notice →
9. DEEU
   Vehiclesinjuries

   Vehicle part / Wheel hub (Meyle) · Wheel hub 514 752 0011

   Defective hardening of the wheel hub may lead to the rear wheel becoming detached. This can lead to the loss of vehicle's control, increasing the risk of accidents and injuries. The product does not comply with the…

   EU Safety Gate · reported by GermanyMeyleOfficial notice →