All-terrain vehicle (Polaris) · Sportsman 850, Sportsman XP 1000, Sportsman XP 1000 S

Water or other contaminants can accumulate on the fuel pump flange, where it can damage the pump flange, which can result in a fuel leak. A leak at the fuel pump’s flange outlet can lead to a risk of fire. The product…

Date

2024-10-04

Country

Germany

Brand

Polaris

Product

All-terrain vehicle

Classification

fire

Category

Vehicles

Source

EU Safety Gate

Copied automatically from the European Commission's Safety Gate. Details may be shortened or out of date; the official notice is the authoritative source. Disclaimer

What to do

1. Check whether your vehicle is affected by entering its VIN (vehicle identification number) on the manufacturer's or the agency's recall lookup.
2. Contact a dealer to book the repair. Recall repairs are normally free of charge.
3. If the notice says not to drive or to park outside, follow that until the repair is done.

General guidance from Recall Atlas. The official notice from the European Commission's Safety Gate has the exact models, batch codes and remedy, and it takes priority.

More Polaris recalls

1. 2025-06-13
2. DEEU
   Vehiclesfire, injuries

   All-terrain vehicle (Polaris) · Ranger

   A crack may occur on a component of the vehicle charging system, allowing water to come into contact with the high voltage components of the charger cable harness. In this case, a short circuit may occur during the…

   EU Safety Gate · reported by GermanyPolarisOfficial notice →
3. 2025-03-21
4. DEEU
   Vehiclesfire

   All-terrain vehicle (Polaris) · RZR XP 1000, RZR XP4 1000

   A missing battery pole cover at the positive pole the starter battery can lead to an electrical short circuit, increasing the risk of the vehicle catching fire. The product does not comply with the Regulation on the…

   EU Safety Gate · reported by GermanyPolarisOfficial notice →
5. 2024-11-22
6. DEEU
   Vehiclesfire, injuries

   All-terrain vehicle (Polaris) · RANGER XP Kinetic (UTV/ Side-By-Side)

   The high-voltage cables on the engine control unit can become detached. This can lead to a voltage arc or overheating, which can result in a fire and/or unintentional acceleration. Moreover, unintentional acceleration…

   EU Safety Gate · reported by GermanyPolarisOfficial notice →
7. 2024-06-21
8. DEEU
   Vehiclesfire, injuries

   All-terrain vehicle (Polaris) · Ranger EV

   Some vehicles have an unprotected wiring harness that can overheat, increasing the risk of fire and serious injury. The product does not comply with the Regulation on the approval and market surveillance of…

   EU Safety Gate · reported by GermanyPolarisOfficial notice →
9. 2023-05-18
10. US
    Vehicles

    Polaris Recalls RZR Pro XP and Turbo R Recreational Off-Road Vehicles Due to Fire Hazard (Recall Alert)

    A fuel leak can occur at the fuel pump assembly joint on the fuel tank in close proximity to a hot surface, posing a fire hazard.

    CPSCAbout 20,330 (In addition, about 330 were sold in Canada)…Official notice →
11. 2023-04-21
12. DEEU
    Vehiclesfire, injuries

    All terrain vehicle (Polaris) · Sportsman 1000S, Scrambler 1000S

    Fuel can to ignite if spilled during refuelling, creating a risk of fire and injury. The product does not comply with the Regulation on the approval and market surveillance of two- or three-wheel vehicles and…

    EU Safety Gate · reported by GermanyPolarisOfficial notice →

Other vehicles recalls in Germany

1. 2024-10-11
2. DEEU
   Vehiclesinjuries

   Vehicle part / Park-and-shunt valve (Haldex) · TEM+

   A production defect can cause the park-and-shunt valve with emergency braking function to release the trailer’s brakes by itself. This can lead to a loss of control over the trailer and increase the risk of accidents…

   EU Safety Gate · reported by GermanyHaldexOfficial notice →
3. DEEU
   Vehiclesinjuries

   Passenger car (Bmw) · 1 series, 3 series, X3, E91 with 8TP

   The propellant in the driver airbag may deteriorate over time. If the airbags deploy, it could result in fragments from the inflator injuring the vehicle's occupants. The product does not comply with the Regulation on…

   EU Safety Gate · reported by GermanyBmwOfficial notice →
4. 2024-10-09
5. DEEU
   Vehiclesinjuries

   Passenger car (BMW ALPINA) · D3, B5, D5, B6, XD3, B3, B4, D4, B3S, B4S

   The propellant in the driver airbag may deteriorate over time. If the airbags deploy, it could result in fragments from the inflator injuring the vehicle's occupants.

   EU Safety Gate · reported by GermanyBMW ALPINAOfficial notice →
6. 2024-10-04
7. DEEU
   Vehiclesinjuries

   Motorcycle (LiveWire) · S2 Del Mar

   In case of repeated acceleration, the high voltage fuse can open, resulting in an unexpected loss of power transmission while moving and no possibility to restart. This increases the risk of accident and injuries. The…

   EU Safety Gate · reported by GermanyLiveWireOfficial notice →
8. DEEU
   Vehiclesinjuries

   Passenger car (BMW ALPINA) · XD3

   Due to faulty rear-most screws, the screw fixings of the boot's lashing rails can fail in the event of a rear-end collision with heavy intrusion and penetrate the backs of the rear seats. This increases the risk of…

   EU Safety Gate · reported by GermanyBMW ALPINAOfficial notice →
9. DEEU
   Vehiclesinjuries

   Passenger van / Light commercial vehicle (Peugeot) · Expert Traveller, Expert

   Incorrectly fitted rear axle suspension springs can lead to a loss of vehicle handling and the spring may come free from its support. The spring can fall onto the road whilst driving, posing a risk of accident and…

   EU Safety Gate · reported by GermanyPeugeotOfficial notice →