Polaris Recalls Ranger XP Kinetic and Pro XD Kinetic Recreational Off-Highway Vehicles (ROVs) Due to Fire Hazard
Water can leak through a cracked filter into the ROV's high-voltage charging harness components and cause a short circuit, posing a fire hazard.
Read the official notice →
- Date
- 2025-06-18
- Country
- United States
- Brand
- Polaris Industries Inc., of Medina, Minnesota
- Product
- Model Year 2023-2024 Ranger XP Kinetic and Model Year 2025 Pro XD Kinetic ROVs
- Units
- About 4,900 ROVs and 185 accessory charger service…
- Category
- Vehicles
- Source
- CPSC
Copied automatically from the US Consumer Product Safety Commission. Details may be shortened or out of date; the official notice is the authoritative source. Disclaimer
What to do
- Check whether your vehicle is affected by entering its VIN (vehicle identification number) on the manufacturer's or the agency's recall lookup.
- Contact a dealer to book the repair. Recall repairs are normally free of charge.
- If the notice says not to drive or to park outside, follow that until the repair is done.
General guidance from Recall Atlas. The official notice from the US Consumer Product Safety Commission has the exact models, batch codes and remedy, and it takes priority.
More Polaris Industries Inc., of Medina, Minnesota recalls
- 2025-10-30
USPolaris Industries Recalls Model Year 2025-2026 Ranger XP 1000 NorthStar and Ranger Crew XP 1000 NorthStar Recreational Off-Road Vehicles (ROVs) Due to Risk of Serious…
An improperly routed alternator cable can become damaged and contact the negative battery post, resulting in an electrical short, posing a fire hazard and risk of serious injury.
CPSCPolaris Industries Inc., of Medina, MinnesotaAbout 5,130 (In addition, about 460 ROVs were sold in…Official notice →- 2025-05-15
- US
Polaris Industries Recalls Ranger XP 1000 NorthStar and Ranger XP 1000 NorthStar Crew Recreational Off-Road Vehicles Due to Injury Hazard
The lower seat belt anchor fasteners were not properly tightened, which can result in the seat belt separating from the vehicle frame, failing to protect riders. Without that protection, riders can be ejected from the…
CPSCPolaris Industries Inc., of Medina, MinnesotaAbout 640 (In addition, about 24 ROVs were sold in Canada)Official notice → - 2025-01-16
- US
Polaris Industries Recalls Model Year 2024-2025 Ranger XD 1500 and Crew XD 1500 Recreational Off-Road Vehicles (ROVs) Due to Injury and Crash Hazards
The door handle can stick and cause the door to unexpectedly open while the vehicle is moving and cause an unrestrained rider to be ejected from the vehicle or increase the risk of a crash, posing serious injury and…
CPSCPolaris Industries Inc., of Medina, MinnesotaAbout 4,200 ROVs and 393 accessory doors (In addition,…Official notice → - 2024-12-05
- US
Polaris Recalls RZR XP 1000 and XP 4 1000 Recreational Off-Road Vehicles (ROVs) Due to Fire Hazard (Recall Alert)
The positive (+) battery terminal cover (red) can become damaged by the seat base, causing the positive (+) battery post to be exposed and contact nearby conductive components, resulting in an electrical short, posing…
CPSCPolaris Industries Inc., of Medina, MinnesotaAbout 21,000 (In addition, about 1,300 were sold in Canada)Official notice → - US
Polaris Recalls Ranger Recreational Off-Road Vehicles and ProXD and Bobcat Utility Task Vehicles Due to Injury Hazard (Recall Alert)
The vehicles' passenger side seat belt anchor point can separate from the frame due to a defective weld on the bracket, posing an injury hazard to passengers from impact with a loose bracket or failure of the seatbelt…
CPSCPolaris Industries Inc., of Medina, MinnesotaAbout 2,500 (In addition, about 130 were sold in Canada)Official notice → - 2024-10-31
- US
Polaris Industries Recalls Ranger XP Kinetic Recreational Off-Road Vehicles (ROVs) Due to Fire and Crash Hazards
The high voltage cables on the motor controller unit can be loose, causing the cable to arc or overheat while in use, posing fire and crash hazards and risk of serious injury.
CPSCPolaris Industries Inc., of Medina, MinnesotaAbout 1,400 (In addition, about 70 were sold in Canada)Official notice →
Other vehicles recalls in the United States
- 2025-06-18
- US
Mazda North American Operations: Incorrect Module Software May Deploy Air Bag Improperly
An air bag that deploys improperly increases the risk of injury during a crash.
- US
Tesla, Inc.: Seat Assembly Fasteners Improperly Tightened
The seat may not properly restrain the occupant, increasing the risk of injury during a crash.
- US
Chrysler (FCA US, LLC): Rearview Image May Not Display/ FMVSS 111
A rearview image that does not display reduces the driver's visibility, increasing the risk of a crash.
- 2025-06-16
- US
Foretravel, Inc.: Rear Kick Up Panel Fins May Detach
A fin that detaches while driving creates a road hazard, increasing the risk of a crash.
- 2025-06-13
- US
Ford Motor Company: Rear Door Window Bars and C-Pillar Trim May Detach
Detached trim may cause a road hazard and increase the risk of a crash.
- US
Ford Motor Company: Back Seat Occupants May Become Trapped
The inability to enter or exit the vehicle in an emergency increases the risk of injury.