Passenger van / Light commercial vehicle (Toyota) · Proace and Proace Verso

Vehicles may have excessive corrosion on the front suspension arm bolt, due to the design in combination with environmental factors. As a result, the bolt may fail which may affect controllability of the vehicle and…

Date

2025-08-15

Country

Portugal

Brand

Toyota

Product

Passenger van / Light commercial vehicle

Classification

injuries

Category

Vehicles

Source

EU Safety Gate

Copied automatically from the European Commission's Safety Gate. Details may be shortened or out of date; the official notice is the authoritative source. Disclaimer

What to do

1. Check whether your vehicle is affected by entering its VIN (vehicle identification number) on the manufacturer's or the agency's recall lookup.
2. Contact a dealer to book the repair. Recall repairs are normally free of charge.
3. If the notice says not to drive or to park outside, follow that until the repair is done.

General guidance from Recall Atlas. The official notice from the European Commission's Safety Gate has the exact models, batch codes and remedy, and it takes priority.

More Toyota recalls

1. 2025-09-11
2. US
   VehiclesVehicle

   Toyota Motor Engineering & Manufacturing: Instrument Panel Failure

   An instrument panel display that does not show critical information can increase the risk of a crash or injury.

   NHTSAToyota Motor Engineering & Manufacturing591,377 affectedOfficial notice →
3. 2025-09-04
4. US
   VehiclesVehicle

   Toyota Motor Engineering & Manufacturing: Inoperative Defrosting and Defogging System

   An inoperative defroster and defogger system can decrease the driver's visibility under certain driving conditions, increasing the risk of a crash.

   NHTSAToyota Motor Engineering & Manufacturing94,320 affectedOfficial notice →
5. 2025-08-15
6. PTEU
   Vehiclesenvironment

   Passenger van / Light commercial vehicle (Toyota) · Proace, Proace Verso, Proace City and Proace City Verso

   A calibration error in the Engine Electronic Control Unit (ECU) software may prevent the Malfunction Indicator Lamp (MIL) from activating when the Selective Catalytic Reduction (SCR) system and/or Diesel Particulate…

   EU Safety Gate · reported by PortugalToyotaOfficial notice →
7. PTEU
   Vehiclesinjuries

   Passenger van / Light commercial vehicle (Toyota) · Proace Max and Proace Max BEV

   When the driver deactivates and reactivates the Automatic Emergency Brake (AEB) in the same driving cycle, it will remain deactivated without a warning light indicating the deactivation. This may increase the risk of…

   EU Safety Gate · reported by PortugalToyotaOfficial notice →
8. 2025-07-25
9. FREU
   Vehiclesinjuries

   Passenger van / Light commercial vehicle (Toyota) · Proace CITY, Proace CITY VERSO, Proace VERSO

   Due to oil carbonisation and high contact pressure, the 7 mm camshaft chain resistance can be reduced. This may cause the camshaft chain to break, leading to an engine failure. This can cause a loss of vehicle's…

   EU Safety Gate · reported by FranceToyotaOfficial notice →
10. 2025-05-15
11. US
    VehiclesVehicle

    Toyota Motor Engineering & Manufacturing: Vehicle Lighting Failure

    Reverse light failure may reduce visibility, and not alert pedestrians and other drivers that the vehicle is backing up, increasing the risk of a crash.

    NHTSAToyota Motor Engineering & Manufacturing443,444 affectedOfficial notice →

Other vehicles recalls in Portugal

1. 2025-09-12
2. PTEU
   Vehiclesinjuries

   Passenger car (Polestar) · Polestar 3

   The hood wing may have been incorrectly attached to the front bumper during manufacturing. In such cases, the hood wing could come loose and detach while driving, which can lead to injuries. The product does not comply…

   EU Safety Gate · reported by PortugalPolestarOfficial notice →
3. 2025-08-15
4. PTEU
   Vehiclesinjuries

   Passenger van / Light commercial vehicle (Lexus, Toyota) · LBX, LM350h, C-HR, Corolla, Corolla Cross, GR Yaris, Highlander, RAV4, Yaris, Yaris Cross

   A flaw in the vehicle's combination meter programming causes it to deteriorate its memory. Due to this the display of the monitor may not work, removing access to the speedometer and warnings. This increases the risk…

   EU Safety Gate · reported by PortugalLexus, ToyotaOfficial notice →
5. PTEU
   Vehiclesenvironment

   Passenger van / Light commercial vehicle (Toyota) · Proace, Proace Verso, Proace City and Proace City Verso

   A calibration error in the Engine Electronic Control Unit (ECU) software may prevent the Malfunction Indicator Lamp (MIL) from activating when the Selective Catalytic Reduction (SCR) system and/or Diesel Particulate…

   EU Safety Gate · reported by PortugalToyotaOfficial notice →
6. PTEU
   Vehiclesinjuries

   Passenger van / Light commercial vehicle (Toyota) · Proace Max and Proace Max BEV

   When the driver deactivates and reactivates the Automatic Emergency Brake (AEB) in the same driving cycle, it will remain deactivated without a warning light indicating the deactivation. This may increase the risk of…

   EU Safety Gate · reported by PortugalToyotaOfficial notice →
7. 2025-07-11
8. PTEU
   Vehiclesinjuries

   Passenger car (Polestar) · Polestar 2

   The vehicle's braking functionality can be disabled while using 'B' mode (in plug-in hybrid cars) or One Pedal Drive (in pure electric cars), after coasting downhill. This can lead to a collision and increase the risk…

   EU Safety Gate · reported by PortugalPolestarOfficial notice →
9. PTEU
   Vehiclesinjuries

   Passenger car (Volvo) · S60, V60, XC60, S90, S90L, V90, XC90, EC40, XC/EX40

   The vehicle's braking functionality can be disabled while using 'B' mode (in plug-in hybrid cars) or One Pedal Drive (in pure electric cars), after coasting downhill. This can lead to a collision and increase the risk…

   EU Safety Gate · reported by PortugalVolvoOfficial notice →