Gillig, LLC: High Voltage Batteries May Short Circuit
A short circuit increases the risk of a fire. In addition, the battery contactors may open suddenly and cause a loss of drive power, increasing the risk of a crash.
Read the official notice →- Date
- 2025-04-01
- Country
- United States
- Brand
- Gillig
- Product
- ELECTRICAL SYSTEM
- Units
- 27 affected
- Category
- Vehicles
- Source
- NHTSA
Copied automatically from the US National Highway Traffic Safety Administration. Details may be shortened or out of date; the official notice is the authoritative source. Disclaimer
What to do
- Check whether your vehicle is affected by entering its VIN (vehicle identification number) on the manufacturer's or the agency's recall lookup.
- Contact a dealer to book the repair. Recall repairs are normally free of charge.
- If the notice says not to drive or to park outside, follow that until the repair is done.
General guidance from Recall Atlas. The official notice from the US National Highway Traffic Safety Administration has the exact models, batch codes and remedy, and it takes priority.
More Gillig recalls
- 2025-12-29
USGillig, LLC: Improperly Tightened Rear Axle Upper Torque Rod Fasteners
Damaged axle components can decrease stability or vehicle control, increasing the risk of a crash.
- 2025-12-16
- US
Gillig, LLC: Wheelchair Restraint Retractor May Not Lock
An unsecured wheelchair can move during transit, increasing the risk of injury.
- 2025-12-15
- US
Gillig, LLC: Emergency Exit Window Latch May Fail/FMVSS 217
A window that opens during a crash may not properly retain passengers, increasing the risk of injury.
- 2025-02-11
- US
Gillig, LLC: Flat Panel Display Monitor May Detach from Ceiling
A monitor that detaches and falls from the ceiling increases the risk of injury.
- 2024-12-20
- US
Gillig, LLC: HV Air Compressor Is Not On Protective HVIL Loop
Failure to alert the operator to a power cable issue can increase the risk of injury by electrical shock.
- US
Gillig, LLC: Damaged Fire Suppression Relay Cable May Fail
Failure of the fire suppression system can increase the risk of injury during a fire.
Other vehicles recalls in the United States
- 2025-04-03
- US
Honda Recalls Accessory Heaters for Side-by-Side Vehicles Due to Fire and Burn Hazards
The recalled accessory heaters can overheat and catch fire, posing fire and burn hazards to consumers.
- 2025-04-02
- US
Jayco, Inc.: Fuel Filter Hoses May Disconnect and Leak Fuel
A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall increases the risk of a crash.
- 2025-04-01
- US
Bollinger Motors, Inc.: High Voltage Battery May Short Circuit
Liquid intrusion into a battery pack can cause a loss of electrical isolation or short circuit, increasing the risk of a fire or shock hazard. In addition, the detection of a battery fault can cause a loss of drive…
- US
BMW of North America, LLC: Starter-Generator Electrical Connection May Fail
A loose starter-generator connection can result in an engine stall, increasing the risk of a crash. In addition, the wiring may overheat, increasing the risk of a fire.
- 2025-03-31
- US
Volkswagen Group of America, Inc.: Instrument Panel Display Failure
An instrument panel display that fails to show critical safety information, such as the speedometer or warning lights, increases the risk of a crash.
- US
Our Next Energy: High Voltage Battery May Short Circuit
Liquid intrusion into a battery pack can cause a loss of electrical isolation or short circuit, increasing the risk of a fire or shock hazard.